i
WARNING: Products on this page can expose you to a chemical, which is known to the St ate of California to cause cancer or reproductive harm. **For more information go to www.P65Warnings.ca.gov**
Gas Heater Pipe Clamp
See "NOS" on website
105
Gas Heater Parts
We have a limited supply of the following new gas heater parts. ORDER NOW!
PICTURE # – Items with are highly suggested.
2. Solenoid Coil C7763 6 oz.
5,6,7,9,10,18,22,23,25. Burner Service Kit: These parts are not available
separately. C7767 4 oz.
13,14. Spark Plug & Gasket C7765 4 oz.
Spark Plug Tool: Set gap and position as shown in Shop Manual. C8106 10 oz.
19. Mixer Cup: Has the "ground electrode" for spark plug. Check yours – if not
"perfect", replace. CX4034 8 oz.
25N. Nozzle C8139 6 oz.
26. NOS Heater Exchanger CX1484 5 lbs.
27. Point Unit CX2194 6 oz.
29. Blower Hose C3806R 1 lb.
30. Ignition Coil C7769 Discontinued
32. Overheat Switch C7770 12 oz.
34. Hoses to Defroster (Enough for both) Fabric C3425 1 lb.
Rubber C3130R 1 lb.
35. Blower Motor C6762 4 lbs.
36. Control Switch: Next to thermostat CX1122 4 oz.
37. Purge Switch CX2192 8 oz.
Gas Heater Spark Plug Tool: For setting gap and position as shown in
Shop Manual. C8106 1 oz.
GAS HEATER ENGINE FUEL FEED LINE: Goes from fuel pump "T" through fire wall. EXACT REPRO for all gas heaters – Car, FC, factory or
original "ADD ON". C11451R 1 lb. 8 oz. For brass connector at fuel pump, see page 65 (C).
GAS HEATER GAS LINES: We supply enough steel gas lines to replace those corroded lines that carry gas from the fuel pump to the gas heater and the extra
back to the tank. Use your old special parts. Feed line from fuel pump see "Y" Page 67.
Enough – No Cutting or Flaring.
Make Larger Bends to "use up" Extra
Enough to Flare. Double Flare
and Make E xact Replacements
1960 Cars C5622 3 lbs. C5623 3 lbs.
1961-65 FC with Gas Heater
C5624 3 lbs. C5624 3 lbs.
Note: Both "Enough" and "Enough to Flare" are the same part number.
Gas Heater Exhaust Pipes
All Cars & FC with GAS HEATERS. Perfect reproduction.
Cars C789R 7 lbs.
Plus UPS AH, see page 204
FC C790R 5 lbs.
Gas Heater Pipe Packing: Car or FC – The originals were asbestos. Our replacements are fiberglass cloth; goes inside
of the clam shell clamp that holds & seals the exhaust pipe to the gas heater. C2404 2 oz.
HEATER–DEFROSTER CABLES
We are manufacturing these cables of material equal to or better than the original GM. In most cases, cables are ready to put right in.
In a few cases you may have to install a clamp. Replace those broken or rusted cables.
Some 1960 cables require that you install old knob. Instructions included.
STAR CLIP: Holds defroster and heater cables on. Usually have to break to get off. 1961-69 – as needed.
C740 1 oz.
CLAMP: Holds heater and defroster cables in place as needed. 1965-69 C3883 1 oz.
Heater Cables 1960 C4308 8 oz.
1961-64 Cars C3342 1 lb.
1961-65 Vans C3340 1 lb.
1965-69 Cars C737R 1 lb.
Defroster Cables
Air Control Cables
1961-64 Cars C3343 1 lb.
1961-65 Vans C3339 1 lb.
1965-69 with A/C C8278 1 lb.
Fan Cable 1960 Only C5647 8 oz.
STAINLESS WIRE & COATED CASING: Like we make our heater control cables from. Use this to make your own control cable. Price per foot is the wire
and casing. Order 1O and get 1O continuous feet. Continuous up to 20 feet! C3714 4 oz./ft
1960 C5646 8 oz.
1961-63 Coupes & 4-Door: Left C3344 1 lb.
Right C3345 1 lb.
1962-63 Convertibles: Set C3348 1 lb./set
1961-65 Vans C3341 1 lb.
1964 Convertibles: Set C3349 1 lb./set
1964 Coupes & 4-Door: Left C3346 1 lb.
Right C3347 1 lb.
1965-69 Cars C937R 8 oz.
Van Cable Clamps – see page 104B
MULTI-KITS
see Blue pg. MK-8
Prev 
