i
WARNING: Products on this page can expose you to a chemical, which is known to the St ate of California to cause cancer or reproductive harm. **For more information go to www.P65Warnings.ca.gov**
235
Engine Grommets
GROMMET USE SHEET – This FREE sheet shows each firewall
and engine shroud grommet and what originally went through each hole.
Thanks to Larry Claypool (The Vair Shop) for this info.! C30G 1 oz.
"A" – Firewall
(BODY)
1960 2 hole – C5057AE 2 oz.
(not exact but works)
1961-64 (exc. fuel return Spyder) & Lakewood battery box
1 hole C5057 2 oz.
1962-64 Spyder (with fuel return) 2 hole C5057AL 2 oz.
"B" – Engine Shroud
1, 2, 3 or 4 hole grommets fit ALL YEARS. Just the number of holes vary.
1961-63 (exc. turbo with fuel return) only need 3 hole
1961-65 (6-14-65) used 4 hole
1965 (6-15-65) - 66 (4-18-66) used 3 hole
1966 (All CORSA) used 3 hole
1966 (4-19-66) (exc. SMOG & CORSA)
& All 67 (exc. Smog) used 1 hole
1967-69 (All SMOG) used 2 hole
“C” – POWERGLIDE MODULATOR LINE GROMMET – 1961-69 All C7364 2 oz.
FC GROMMETS – Most grommets & plastic plugs shown on this page also fit FC's.
Battery Wire Grommet – 61-62 Wagons – C5057 2 oz.
1965 Battery Area Grommet – Includes the rubber drain hose holes, but we have filled those
in with a thin skin of rubber as few owners still use the drains. Not all 65's had these. C6894G 2 oz.
BLACK PLASTIC PLUGS FOR ENGINE COMPARTMENT
Disc.
4½
PICTURE # FOR 1961-64 ALL
1. 1961-64 All with standard transmission - Front Shroud C4225 1 oz.
2. Below Cool Air Duct – Front of engine "firewall " C4228 2 oz.
3. Above Spare Tire – 2 needed C4227 2 oz.
3½. Bottom of 1961-64 spare tire area C7582 4 oz.
4. Large plug near battery – 2 different sizes were used: 2½" C4228 2 oz.
(Check your car) 2¾" C4229 2 oz.
4½. Plug Above Battery C4227 2 oz.
5. 1962-64 Convertibles Only – Oblong shape C4226 1 oz.
6 & 7. 1961-64 4-Door – Rectangular and 1961-64 2-Door C1313 4 oz.
Rectangular. Same plug different location.
Black Rubber Hose by the foot – Vacuum & fuel – See page 71
ENGINE SEAL WEATHERSTRIPS TO BODY – See page 8
STEERING BOX PLASTIC PLUGS
Adjusting hole cover in trunk. 1960-69 C3761 1 oz.
VAN SILVER PLUGS
FC SILVER COVER: Covers oval holes along the sides. All Vans & Rampsides. 1961-64 (exc. Greenbrier).
These are supposed to be one piece, but the only way we can supply is as a 2-piece that butts in the middle.
Sold set/2 pieces to cover one hole C2081X 2 oz.
FC ROUND SILVER PLASTIC COVER: Used around doors, side ramps on 1961-65 FC's. Reproduction.
C5964T 1 oz. ea.
GAS TANK FILLER SEAL: Large round rubber seal that goes around the neck and seals to the body.
1961-69 Cars C536R 8 oz.
Vans – EXACT REPRO C10875 8 oz.
REAR GAS LINE GROMMETS (60-64 CARS – Also see page 98B)
Where gas & brake lines come out of rear of tunnel.
1960-64 All Cars – 3 were used for each year. 2 identical large ones and one shorter. (Hole diameters
vary slightly). We sell only the large one. Just cut with a knife and
it equals the short one. C7241 2 oz.
1965-69 ALL CARS – This grommet fits above the clutch cable
boot (standards) and the rear plate on PG.
C528R 1 oz.
Discontinued
Use 2 hole
C6583
C4999
C6724 C6724B C5058
C6894G
C7364
Prev 
